can the copper slag be used instead of sand in concrete

• 

  Experimental Investigation on the Mechanical Properties of ...

  properties by substituting copper slag for sand partially in concrete. For sand replacement, four test groups ... Alternate material need to be used instead of this natural materials. At the same time industrial waste is ... To find the optimum proportion of copper slag that can be used as a replacement/ substitute material for fine aggregate.

  Get Price >
• 

  An Experimental Study on Partial Eplacement of Cement by ...

  parameters of the concrete. So I am using copper slag as a one of the constituent alternative material for sand in concrete about 50% by weight of sand. For my project I collected the copper slag JSW jindal, Hospet. Figure 2: Copper Slag.

  Copper slag as fine aggregate for high performance concrete

  study the potential use of copper slag as fine aggregate on the strength of both normal and high strength concrete. Concrete mixtures were prepared using different proportions of copper slag as partial and full replacement of fine aggregate. The percentage of copper slag added by weight ranged between 10- of sand used in concrete.

  Get Price >
• 

  Concrete Mix Design Using Copper Slag as Fine Aggregate ...

  end up with equal volume of concrete as that of control mix when copper slag used as natural sand. Therefore modified mix proportion = 1: 2.52: 3.76 with w/c = 0.45 and Modified concrete mixtures with different proportion of copper slag as shown in Table 3.

  Get Price >
• 

  Effect of copper slag as a fine aggregate on the ...

  An experimental investigation was conducted to study the effect of using copper slag as a fine aggregate on the properties of cement mortars and concrete. Various mortar and concrete mixtures were prepared with different proportions of copper slag ranging from 0% (for the control mixture) to as fine aggregates replacement.

  Get Price >
• 

  Copper slag sandblasting abrasives - Abrasive blasting

  Copper slag abrasive is dense enough to be reclaimed via a Cyclone separator in coarser sizes only. It has a 115 to 120#'s/cubic foot. THIS IS A HIGHER DENSITY THAN COAL SLAG AND WILL THUS BLAST FASTER THAN COAL SLAG, AND YOU CAN RECLAIM IT A COUPLE OF TIMES AS WELL.

  Get Price >
• 

  Mechanical Properties and Durability of Concrete with ...

  It can be seen that the sand and copper slag materials had a very similar grading, with D 90 of 1.2 and 1.9 mm for the copper slag and sand respectively, D 50 of 0.47 and 0.54 mm for the sand and copper slag respectively and D 10 of 0.22 mm for both materials, and a coefficient of uniformity of 2.91 and 2.51 for the slag and sand respectively. This confirms the suitability of the slag for use as fine concrete .

  Get Price >
• 

  Use of furnace slag and welding slag as replacement for ...

  So, the present study focuses to replace sand by welding slag (WS) and furnace slag (FS) in the production of concrete. Properties of aggregates and slag were studied in detail. M25 concrete was designed for various percentages of slag, and compressive strength of concrete was found out.

  Get Price >
• 

  Influence of Copper Slag in Concrete as Partial ...

  1) The use of copper slag in the concrete as a replacement for fine aggregate, reduces the costs of disposal, lowers the cost of the concrete and also helps in protecting the environment. 2) In this project M20 and M40 grade concrete are prepare with different ratios of copperslag instead of fine aggregate and also finding the optimum percentage of copper slag used in concrete.

  Get Price >
• 

  buy Granulated Copper Slag - high quality Manufacturers ...

  We can offer granulated slag, copper slag and flyash in bulk used for various purposes like cement i We can offer granulated slag, copper slag and flyash in bulk used for various purposes like cement industry, abrasive, land filling etc..

  Get Price >
• 

  AN EXPERIMENTAL INVESTIGATION ON STRENGTH .

  concrete by using copper slag as a partial replacement of river sand, also the optimum percentage of copper slag as a partial replacement of sand has been established to 40%.

  Get Price >
• 

  Slag - Wikipedia

  During the early 20th century, iron ore slag was also ground to a powder and used to make agate glass, also known as slag glass. Modern uses. Ground granulated slag is often used in concrete in combination with Portland cement as part of a blended cement. Ground granulated slag reacts with water to produce cementitious properties.

  re use copper slag

  Can sand blasting abrasive be reused such as copper slag Yes it can, you can buy a sort of funnel with about 1 sq. ft. of fine screen in it to filter the junk out of the blasting media. I reuse mine until it just quits cutting or gets so fine that it blows away.

  Get Price >
• 

  Common Uses for Slag | National Slag Association

  Crushed and graded - for concrete aggregates, concrete sand, glass insulation wool, filter medium, and use under concrete slabs as a platform 2. By passing the molten slag through high volume high pressure water sprays, a glassy, sand-Type (granulated) material Is formed, known as Granulated Blast Furnace SIag.The color of this product is very ...

  Get Price >
• 

  What is a Copper Slag? (with pictures)

  Oct 12, 2018· Contractors may also use copper slag in place of sand during concrete construction. The slag serves as a fine, or binding agent, which helps hold the larger gravel particles within the concrete together. When used in this manner, the slag helps to improve the properties of the concrete, and also serves as a form of recycling. ...

  Get Price >
• 

  Concrete without sand?

  The new application of copper slag as a partial substitute for sand also triggered the change of the Singapore's Aggregates Standards which allows both natural and non-natural aggregates, including recycled aggregates, in concrete, thereby, opening the door to the use of more recycled/waste materials in concrete production.

  Get Price >
• 

  Nonferrous Slags - Material Description - RMRC

  Nonferrous Slags - Asphalt Concrete INTRODUCTION A variety of nonferrous slags (air-cooled or granulated) including phosphorus, copper, nickel, and zinc slags, can be used as coarse and/or fine aggregate in hot mix asphalt pavements.

  Get Price >
• 

  Copper Crusher Slag – Grinding Mill China

  Copper Crusher Slag [ 4.7 - 6621 Ratings ] The Gulin product line, consisting of more than 30 machines, sets the standard for our industry. ... can the copper slag be used instead of sand in concrete. ... (WCS) as a substitute for sand in the production of concrete is ... » Learn More. slag composition gold - Copper Ore Crusher.

  Nonferrous Slags - Material Description - User Guidelines ...

  Phosphorus, copper, and nickel slags have been used as aggregate substitutes in hot mix paving. Air-cooled slags can be used as coarse or fine aggregate, while granulated slags can be used as fine aggregate. (1) Granular Base, Embankment, and Fill. There has been limited use of copper, nickel, and phosphorus nonferrous slags as a granular base material.

  Get Price >
• 

  Copper slag as sand replacement for high performance ...

  title = "Copper slag as sand replacement for high performance concrete", abstract = "This paper reports on an experimental program to investigate the effect of using copper slag as a replacement of sand on the properties of high performance concrete (HPC).

  Get Price >
• 

  STUDY ON MECHANICAL PROPERTIES OF CONCRETE WITH .

  Copper slag is a waste material produced from copper manufacturing process and this can be used as a replacement material for fine aggregate (sand) since the particle size similar to sand. During the present study, an attempt

  Get Price >
• 

  Nonferrous Slags - Material Description - User Guidelines ...

  Granulated copper slag is more porous and therefore has lower specific gravity and higher absorption than air-cooled copper slag. The granulated copper slag is made up of regularly shaped, angular particles, mostly between 4.75 mm (3/4 in) and 0.075 mm (No. 200 sieve) in size.

  Get Price >
• 

  lead slag used in concrete industry

  Lead Slag Used In Concrete Industry, process crusher, mining ... use of copper slag in concrete in india ... Ltd. Slag pot, ... more price-competitive binder that can be used instead of conventional cement for ... Global lead slag buyers find ... Effect of steel slag and Portland cement in the rate of hydration ... · PDF .

  Get Price >
• 

  Evaluation on Accelerated Corrosion Properties of the ...

  Fine aggregate: Fine aggregates used for conventional concrete are river sand and copper slag. Nearby accessible sand belonging to zone-II of IS: 383-1970 is used. Copper slag is procured from Mythri Metallizing Private Limited, Bangalore, Karnataka, India. The physical features of fine aggregate are presented in table 3.

  Get Price >
• 

  Sustainable Construction - Building & Construction Authority

  The treated spent copper slag can be recycled and put to good use as sand replacement in concrete. For structural usage, the use of copper slag as partial replacement of sand in concrete is allowed for up to 10% by mass.

  Get Price >
• 

  Copper Slag - General Information, Process, Products ...

  Contractors may also use copper slag in place of sand during concrete construction. Copper slag can also be used as a building material, formed into blocks. Copper slag is widely used in the sand blasting industry and it has been used in the manufacture of abrasive tools.

  Get Price >
• 

  Concrete mix design using copper slag as fine aggregate

  CONCLUSIONS Copper slag can be used as an alternative to natural sand in concrete. When copper slag(CS) is replaced with equivalent weight because of the fact more mortar is there to surround the aggregate therefore may workability will increase in terms of slump, however the compaction factor is more or less same comparable to that of the natural sand.

  Get Price >
• 

  The Copper Slag Used Instead Sand Concrete

  copper slag sand can be used for concret - . Can The Copper Slag Be Used Instead Of Sand In Concrete. must copper slag sand can be used for concret - copper slag sand can be used for concret - rrcser.

  Get Price >
• 

  can copper slag be used for slag cement

  Use of Copper Slag and Fly Ash in High Strength Concrete Use of Copper Slag and Fly Ash in High slag can be used as replacement of sand and 18% fly ash can be . Chat Now can the copper slag be used instead of sand in concrete

  Get Price >
• 

  An experimental of strength properties of concrete admixed ...

  instead of part of the construction sand [12]; Li Feng's research showed that: copper slag have the same physical and mechanical properties and durability with the ordinary concrete [13]; Du Hongyong and others have produced

  Get Price >
• 

  process of making construction sand from copper slag ...

  can the copper slag be used instead of sand in concrete .manufacturing process are limestone, clay, sand,use copper slag in place of sand during concrete » Learn More Studies on use of Copper Slag as Replacement Material fo

  Get Price >
• 

  Can Copper Slag Be Recycled

  Can The Copper Slag Be Used Instead Of Sand In Concrete. How to Recycle Copper Slag. ... has become a popular and cheap alternative to sand for use in ... concrete is a form of sustainable concrete that can be used instead ... can the copper slag be used instead of sand in concrete Overview. ... copper slag sand can be used for concret Quarry Crusher ...

  Get Price >
• 

  re use copper slag

  Can sand blasting abrasive be reused such as copper slag Yes it can, you can buy a sort of funnel with about 1 sq. ft. of fine screen in it to filter the junk out of the blasting media. I reuse mine until it just quits cutting or gets so fine that it blows away.

  Get Price >